Forklift Operator Exam IV Copy

Sound your horn to warn others when you approach a blind spot.

You may park your forklift in front of fire fighting equipment.

When it is raining and you are outside, you should drive faster so your tires and brakes don’t get too wet.

When the load blocks your visibility it is okay to drive with it raised if there are no pedestrians in the general area.

The load capacity of your forklift is listed on the data plate.

Sound your horn when you approach pedestrians standing or walking.

Allow three vehicle turn lengths when following another forklift.

The weight of the load affects the center of gravity in the stability triangle.

If your rear wheels raise off the ground when lifting a load, have someone stand on the back of the forklift to counter the action.

A professional operator always plans his route ahead to avoid obstacles.

Since the rear wheels are the ones that turn, the back end of the forklift tends to swing wide when cornering.

It is not the operator’s responsibility to report slippery condition in high traffic areas.

Stunt driving is okay if you do it after hours.

When picking up a load, the forks should be level and spread as wide as possible to enter the pallet.

A forklift always has the right-of-way in your facility.

Steel support jacks should be used when a truck trailer is not connected to the cab.

Forklift designations are given on wet or slippery surfaces.

You should drive a reduced speed on wet or slippery surfaces.

If your load weighs 4,000 pounds, it is probably safe to enter a truck with a 5,000 pound capacity.

Material may be left in aisles and roadways if 12 inches are left to get by.

The front wheels are turning wheels.

If a forklift needs repairs, tag the lift truck and remove it from service.

Always hand-tighten the propane cylinder connections and check for leaks after connecting

When the center of gravity shifts outside the stability triangle, the odds of tipping the forklift decrease.

In the event of an rollover you should?

Forklift must travel with load close to ground and at safe speed.

Forklift refueling and battery charging and replacement are preformed in:

Prior to initial start-up, the following items must be checked (select all that apply):

In the event of an overturning forklift, the operator shall:

If more than one operator will use the forklift during one shift, only the first operator needs to perform and document the inspection.

The signal that the operator may take from anyone is the signal to:

Tip-overs are the most common cause of forklift fatalities.

An operator may continue to run equipment if he/she does not have their designated forklift operator card in possession.

Which of the following shall be clearly posted on the forklift?

A forklift operator may leave the fork attachment suspended after shift if insufficient room is available to lower the attachment.

The forklift load chart shows a rating of 2220 kg at a 600 mm load center. What does this mean?

What procedure do you follow when the load on your forklift obscures your view in front?

How should you normally drive your forklift?

A fault occurs while driving your forklift.  What action do you take?

A fault occurs while driving your forklift.  What action do you take?

What position should the forks be in while driving a forklift?

What position do you place the forks when parking your forklift?

Who is responsible for the safety of persons working in a forklift area?

When must you use the back tilt on your forklift when traveling?

When driving an empty forklift down a ramp, in what direction should the forks point?

Is the carrying of passengers allowed on forklifts?

Are fork extensions permitted where a load is too long?

When is the forklift operator required to look in the direction of travel?

How should the rated capacity of a forklift be determined by you?

How often is a forklift operator required to check the brakes?

What action is required when a load is unstable?

Are you allowed to turn a forklift on a ramp or slope?

Should the load capacity of a forklift ever be exceeded?

In what position should a gas cylinder safety valve be when fitted to a forklift?

Is it permissible to tow a railway wagon using a forklift?